From: Stu (stuinnh@comcast.net)
Date: Thu Dec 18 2003 - 12:54:35 PST
Manual says push pedal half way in warm weather to start, and all the way in
cold weather.
"Stu"
Southern New Hampshire, USA
"Live Free Or Die"
Military Vehicle Preservation Assoc.
Merrimack Valley Military Vehicle Collectors
Green Mountain Military Vehicle Club
Vehicles:
1967 M151A1 Jeep
1964 M416 1/4 Ton Trailer
1986 M1009 CUCV Blazer
-----Original Message-----
From: Military Vehicles Mailing List [mailto:mil-veh@mil-veh.org] On Behalf
Of Jim Newton
Sent: Thursday, December 18, 2003 3:50 PM
To: Military Vehicles Mailing List
Subject: [MV] Can a CUCV 6.2 Diesel Get "Flooded" at Start-Up?
Hi All...
Last weekend I went down to check out Sean Nichols' deuce, and it is
looking really great.
When I started my CUCV after lunch, it didn't seem to spark at
all...just cranked and cranked. Usually it will fire up in a single
turn of the engine...I can just pop the key and it roars to life.
So here's what I tried:
o I manually activated the glow plugs by jumping the relay (the
engine was already warm so it should not have needed the glow plugs).
It still wouldn't start.
o I checked fuel flow through the fuel filter base (with the little
valves) and fuel ran right out. It runs really great on the freeway
(up to 85 or 90 easy) so I know the fuel filter is not dirty, and I
just replaced it a few months ago.
o I checked all visible electrical and hose connections, didn't see
anything loose.
o The engine exhaust smelled like raw diesel, so I'm pretty sure it
was getting fuel.
After a while of letting it sit, I just cranked the heck out of it and
eventually it fired up. It concerned me a lot because this truck has
always been a dream to start up.
Usually I do not push the gas pedal when I start it up. If I pushed
on it, is it possible that the engine could have been "flooded" with
too much diesel fuel and wouldn't fire?
Thanks!
--Jim "Ike" Newton
o 1984 M1007 CUCV Military Suburban 6.2 Liter (378 CID) Turbo-Diesel Engine 5/4 Ton Cargo Capacity, 4WD
o 1971 M35A2 Military Troop/Cargo Truck "Deuce and a Half" 478 CID Turbo-Diesel Multi-Fuel Engine Air Shift Front Axle 2 1/2 Ton Cargo Capacity, 6WD
See These Trucks at www.CUCV.NET Keyword Searching of 22,000 Electronic TMs at www.MILDOCS.com
=Mil-Veh is a member-supported mailing list= To unsubscribe, send e-mail to: <mil-veh-off@mil-veh.org> To switch to the DIGEST mode, send e-mail to <mil-veh-digest@mil-veh.org> To reach a human, contact <ack@mil-veh.org>
This archive was generated by hypermail 2.1.4 : Sat May 07 2005 - 20:26:58 PDT