Re: {**Possible UCE**} CUCV Starter

From: Dennis M. Hankey (dmhankey@grandcounty.com)
Date: Sun Apr 02 2006 - 18:28:59 PDT

Answer: NO, and with that I will get on it an see if that solves the
problem. I must tell you that stamped on the case of the starter casting
are the words " NO SHIMS". I'll review the TM and report back. Thanks

----- Original Message -----
From: "James Shanks" <n1vbn@yahoo.com>
To: "Military Vehicles Mailing List" <mil-veh@mil-veh.org>
Sent: Sunday, April 02, 2006 4:01 AM
Subject: Re: [MV] {**Possible UCE**} [MV] CUCV Starter

> Did you install the starter with the shim or
> without? The CUCV requires a shim for correct
> bendix engagement.
>
> Jim
> 1985 M-1009
>
>
>
> --- "Dennis M. Hankey" <dmhankey@grandcounty.com>
> wrote:
>
> > TO ALL:
> > Stumper of the week!! Installed new ring gear.
> > Started many times after
> > that just fine. Now sometimes from time to
> > time there is a heck of a noise,
> > something slipping , no engagement, no
> > starting. Removed starter cleaned,
> > replaced starter lever as the ears were warn
> > and there was an indication the
> > gear was not fully engageing. Noticed some
> > nicked ring gear teeth. Open
> > solanoid, inspecteded and reversed the round
> > contact plate. Reinstalled,
> > started many times there after ok. Now three
> > days later again same problem.
> > Removed starter and replaced starter driver
> > with new part. Noticed more
> > nicks on ring. On fifth start same problem.
> > Could it be that the solanoid
> > starts the starter turning before the gear is
> > engaged?? Any answers on what
> > I'm missing here??
> > Thanks Dennis Hankey M1009
> >
> >
> > ===Mil-Veh is a member-supported mailing
> > list===
> > To unsubscribe, send e-mail to
> > <mil-veh-off@mil-veh.org>
> > To reach a human, contact <ackyle@gmail.com>
> > Visit the searchable archives at
> > http://www.mil-veh.org/archives/
> >
>
>
> __________________________________________________
> Do You Yahoo!?
> Tired of spam? Yahoo! Mail has the best spam protection around
> http://mail.yahoo.com
>
> ===Mil-Veh is a member-supported mailing list===
> To unsubscribe, send e-mail to <mil-veh-off@mil-veh.org>
> To reach a human, contact <ackyle@gmail.com>
> Visit the searchable archives at http://www.mil-veh.org/archives/
>

This archive was generated by hypermail 2.1.4 : Tue Jul 18 2006 - 21:43:34 PDT